Jump Main Menu. Go directly to the main content

Grupo Cementos Portland ValderrivasGrupo Cementos Portland Valderrivas

  • We produce in a sustainable manner caring for the planet

  • We operate in Europe, Africa and United States

  • Cement, concrete, aggregate, mortar and recycling

  • The architectural challenges are built with us

  • We’re leaders in our markets

  • Specific cements and experienced teams

  • From the seashore we arrive where is needed

  • Committed to quality and the environment

  • We make It happen

You are in:
  1. Range of products: Adhesive cement

Range of products: Adhesive cement

Range of products: Adhesive cement

Valcol Juntas

Tile grouting mortar.

Special mortar for indoor and outdoor wall and pavement grouting.

Type CG2 (UNE EN 13888).

Available range:

  • Thin grout (3 mm).
  • Universal grout (3-15 mm).
  • See colour chart.
Tile size (cm)Tile thickness (mm)Joint width
2 to 4 mm5 to 8 mm9 to 12 mm
15x15 5 0,7 kg/m2 1,1 kg/m2 1,6 kg/m2
20x20 6-8 0,6 kg/m2 1,0 kg/m2 1,5 kg/m2
33x33 8 0,5 kg/m2 0,9 kg/m2 1,4 kg/m2
45x45 8-10 0,4 kg/m2 0,8 kg/m2 1,3 kg/m2
Grandes formatos 10-12 a consultar a consultar  a consultar
Supply conditions

25 kg bags protected by plastic sheet.


Ask for the range of available colours. .

Mixing instructions

Add 6 litres of water per bag of VALCOL JUNTA UNIVERSAL, i.e. 0.30 litres/kg. Mix by hand or with a slow electric mixer until obtaining a smooth paste. The consistency should be that of cement–based adhesive. Let stand for 5 minutes before using. Then mix again.

The working time for VALCOL JUNTA UNIVERSAL is approximately 90 minutes from preparation.

Substrate preparation

Joints between tiles should be dry and clean (i.e. without dust, surface grout, loose particles or any other material that impedes good adhesion).

It is advisable to wait 24-48 hours after laying the pavement before grouting. When grouting porous or rough ceramic tiles, protect them with a primer to avoid staining and for ease of cleaning.


Mortar made from cement, graded aggregate, resins, organic and inorganic admixtures, and pigments.

Tipo CG2 según norma UNE EN 13888
Abrasion resistance (UNE EN 12808-2) ≤ 1000 mm3 Mixing water 30% ± 1%
Flexural strength (UNE EN 12808-3) ≥ 3,5 N/mm2 UNE EN 1015-6 Apparent density 1,4 ± 0,2 kg/l
Flexural strength after freeze-thaw cycle (UNE EN 12808-3) ≥ 3,5 N/mm2 Working temperature +5ºC a +35ºC
Compressive strength (UNE EN 12808-3) ≥ 15 N/mm2 Grouting time ≥ 24h
Compressive strength after freeze-thaw cycle (UNE EN 12808-3) ≥ 15 N/mm2 Water absorption after 30 min. (EN 12808-5) ≤ 2 g
Water absorption after 30 min. (EN 12808-5) ≤ 5 g
Instructions for application

Spread VALCOL JUNTA UNIVERSAL on the joint with rubber float, working diagonally and ensuring that the grout penetrates properly.

Once the grout starts to harden, when the surface sheen of VALCOL JUNTA UNIVERSAL begins to fade, remove excess grout with a wet sponge. Apply to a small area at a time, cleaning as you go. Final cleaning, with a dry or damp cloth, should be done once the grout has hardened.

Do not use the product at an ambient temperature below 5ºC or above 35ºC.


VALCOL JUNTA UNIVERSAL fulfils the requirements of the UNE EN 13888 quality standard.

VALCOL cement mortar is produced in Industrial Dry Mortar plants with Quality Assurance Systems certified by AENOR in accordance with the UNE EN ISO 9001:2000 standard.

The data is based on trials performed in our control laboratory and is the result of extensive experience with the products made by Cementos Portland Valderrivas Group. Different site conditions may lead to variations in some of the data.


Store in a dry place, protected from frost and direct sunlight. When stored appropriately, the product may be used for up to 12 months from the date of manufacture.


This product contains cement. Avoid contact with eyes and skin and do not inhale the dust. Wear rubber gloves and goggles. Keep out of reach of children.

Note: Cementos Portland Valderrivas is not responsible for inappropriate use of the product or for unexpected outcomes arising from its usage, since the application conditions and methods are beyond our control. The customer is responsible for ensuring correct use of the product.

© Cementos Portland Valderrivas 2018. All rights reserved.